2012 fuel pressure regulator
I'm getting low fuel pressure symptoms so I bought a new fuel pump kit that came with a new regulator. It's stamped 350kpa. Is this the right one?
View ArticleClik here to view.
Unknown O Ring
What is this o ring for that came in the gasket set? Attached Thumbnails Â
View ArticleEngine Noise from Valve Cover
I just finished doing pinion nut repair on my 2012 RZR 800, replaced all the wheel bearings and put on new tie rod ends, and before I re-install the bed I wanted to complete a few other items. My unit...
View ArticleStock rzr 800 shocks any one running max height on dampening?
Hey guys I have the old sagg in my shocks can't afford new springs right now. Just wondering anyone running full dampening fornthe extra height . Is the ride much rougher? Really want the extra height .
View ArticleWere there shock options for the 800 trail?
While riding this weekend I had to re-plug my one tire yet again and we noticed that my rear shocks were quite a bit bigger in diameter on my 2014 800 than on my buddies 2012 800. I never noticed this...
View ArticleClik here to view.
Looking for advice on buying a Rzr
Hey all, I'm in the market to get a side by side and looking for some advice on what to get and look for as far as common issues go. Ups and downs of the 800 vs the 900 and 1000? I found this 2010 800...
View ArticleBelt got wet in not very deep water
2012 800 4 seater. I drove through some water that might have been tire high on stock 25 and got the belt wet. Not flooded or anything, just wet. The clutch cover would have definitely been underwater...
View ArticleClik here to view.
08 rzr 800 not running
Hello, I'm new to the rzr world I recently bought a 08 rzr 800 I rebuilt the top end and everything worked well I was 3/4 threw the break in tank of gas. It was running and driving great. So today I...
View Article07 rzr 800 no rear wheel drive
So something interesting I cant figure out. I just picked up this rzr800. I jacked up the back and the rear wheels spin freely. I put it in drive and nothing. I switch it to awd and the front wheels...
View ArticleRide from hell in the trails-need shocks
Ok so tell me if this is normal on the 800's. You're riding hard and fast. You get to some roughness in the red clay hard dirt trails and your front shocks go BAM BAM BAM BAM BAM...you get through it...
View Article2009 rzr melted engine ground
After a few weeks of sitting went to start my rzr and the ground wire coming from the engine got so hot it melted and actually started a small fire that was put out right away. All grounds have been...
View ArticleClik here to view.
'Welding' fuel tank with soldering iron
After installing doors on my 2009 RZR 800S I noticed a steady drip of gas under the passenger seat when the tank was full. I removed the door, trip, rocker panel, etc and found that the drip was...
View ArticleInline fan or bike man clutch cover?
I came across this online as a suggested part after looking up and buying a new oversized radiator and wondered if its worth the 200 bucks to get one? Also it only claims to add 50cfm at idle.Would I...
View ArticleClik here to view.
Greetings from Va
Greetings all, picked up a new to me 2014 Rzr 800 yesterday with 1100 miles and 170 hours. . Its been upgraded in the past as more of a mud ride with 28" mega mayhems, SATV 1.5-3" lift, and some kind...
View ArticlePinion nut info or contact
I just purchased a 2012 razor 800s orange madness and black..I already have a General to take the wife and dogs cruising..The razor will be kinda my toy and a loaner for visitors. It's got 4300 miles...
View Article