Sunk
I sunk my rzr 800 it cranks up and runs ok it makes a loud whistleing noise ive checked the oil gas and took the air filter off i cant find out what it is help
View ArticleHOMEMADE HAND CONTROLS
I am in a wheelchair due too a failed back surgery, and use a UTV to get around my area, as long as I stay off federal roads it is allowed in my area. I use to drive a Kawasaki mule one of the 1st...
View ArticleNew here
I just bought a 2012 RZR 800. Has 325 miles on it and has never seen mud [emoji15]was a camp ground cart it appears. I know nothing about it other than its got more power than I expected. Doing a lot...
View ArticlePinion nut DONE!
2013 800s 5000 miles decided to check my pinion nut. Yes blue nylock nut, yes it was loose. Guess I got lucky. Replaced with the newer style nut and thread locked, replaced all the seals. All set and...
View ArticleBrand new stator half charging?
Hey guys, I'm new to the forum since RZR Nation on facebook wasn't much help. I had charging issues when I first bought my 2009 rzr 800, and after buying a new regulator/rectifier, I realized my...
View ArticleRzr 800 prop shaft interchange?
Anyone know if prop shaft from 2011 rzr 800 will for the 09-10 rzr 800?
View ArticleSNOW PLOWS
I bought my RZR using the main excuse to my wife that I could use it to push snow, my last SxS being a 1st generation Kawasaki Mule had no heat . Now that I have it, I have already bought new heavy...
View Article2011 RZR 800 no spark
I need some help guys. I road my bike the other day and everything was good. Parked it for about 2 days. Went to crank it up to move it and it wouldn't crank it would just spin over. So I checked the...
View ArticleRzr 800 cheap power steering
So recently I purchased a used eps unit and shafts from eBay from a 2013 900xp I am needing some help on wiring it up though I know where the power and ground are but there is also an 8 pin connector...
View ArticleRoof/Boat Racks for RZR 800
I live in Northwestern Ontario and am surrounded by small lakes. Many of these small lakes have four-wheeler access but are rarely fished. I have driven into a few of these lakes with my RZR 800 and...
View ArticleNeed the Airtex Fuel Pump Number
Fellow on another forum may need a new fuel pump for a 2010 800. I've always meant to write it down and keep it but never got around to it. Anybody got the number. TIA Mike
View Article2011 rzr 800
So I have a 2011 rzr 800 On 31 bkts and it will not go over 35 mph and over 5000 rpm in high I put a fuel programmer on it to see if it would help but it didn’t does anyone know what the problem could...
View Article2014 RZR 800 Loss of power
I bought this RZR and had a loss of power with check engine light and it was the TPS sensor. I fixed it and now when I hit full throttle it lugs down for a couple seconds and then will run fine until...
View Article2013 rzr 800
Got my razor in some high water. Crank runs fine, once it gets to 20mph it will cut off! Changed fuel pump , filter , drained gas but still the same thing! No check engine light! Any ideas????
View ArticleClik here to view.
One way bearing?
It has been suggested that the chirping noise my clutch makes as it disengages is a bad one way bearing. Tried to post a video with sound by it wouldn't upload. Which is the "one way" bearing in the...
View ArticleTried to message Les (pullerguy).
I have been putting the pinion nut repair off on my two machines and since we are planning a trip to Estes park next month,, is like to get it done. I couldn't get a message to send to les. I didn't...
View ArticleClik here to view.
Rear differential options
I am buying my first RZR Monday, a 2008 800. It needs a rear differential (it actually moves if you put it in awd). How hard is it going to be to find a complete one, preferably used? I see them on...
View Article2011 RZR 800 - fuel pooling on top of fuel pump housing????
Was hitting the trails today and had a strong fuel smell..... when I got home I pulled the passenger seat and saw a pool of fuel on top of the fuel pump housing.... I could not see a leak at the...
View Article2010 with lift - can i put on 27 inch tires?
2010 - could use some more ground clearance.. But also heard that 27 inch tires might mess up the clutch or such? Sorry... not very mechanical and looking for advice.
View ArticleSeat sliders
I just bought a 2014 800s for my wife and daughter to share is there and seat slides out there
View Article
