Performance Upgrades
I mainly ride at the Dunes and would like a little more low end torque and possible more top end speed, what upgrades has anyone had good results with. Has anyone heard of sending off the computer to...
View Article14 paddle dune tire too much?
I have found a deal on a used set of sand slinger paddle tires on MSA wheels , they have 14 paddles on the rear 27 x 13 x 14 and full buff fronts 27 x 10 x 14 RZR is an 2011 RZR 800 completely stock,...
View ArticleClik here to view.
PRP Door Latches
Well I scored a sweet deal on some brand new in-box in-plastic PRP doors for my 2010 RZR 800. Not only were they only $300 and NIB, they were 20min down the highway! :big-grin Only one catch...the...
View Articlesurging engine
I have a 2014 800S and it just developed a problem. It starts great and appears to idle fine, however as soon as I give it gas, it starts to accelerate then falters, then starts to accelerate and...
View Article2012 rzr 800 4 Gordon edition smells very rich
I have a 2012 rzr 800 4 that smell very rich like a race car but only during hard acceleration. There is no smoke machine has approximately 2200 miles. Any ideas on what could be causing it? Thanks in...
View ArticleRotella Oil in 2011 RZR 800S
Guys for you that use Rotella oil in the 800s I would like to know if I got the right stuff. I bought: Rotella T6 Synthetic Heavy Duty Diesel Engine Oil 5W-40 The only thing that worries me is the...
View ArticleQuiet muffler?
Is there any inexpensive way to quiet the muffler? It seems way too loud. Thanks,
View ArticleClicking Noise from front axle or hubs after changing steering linkage
We have a RZR 800 2008. Changed the entire steering linkage with a new heavy duty preassembled system which was entirely built. We just needed to get the old one off which was a challenge. The new net...
View Article2011 RZR 800 leaky valve cover
Pulled the valve cover today (leaft the header on). The seal failed in several spots and was flat above the header.... new seal, new reed, new reed gasket and new billet pcv breather.
View ArticleClik here to view.
Am I missing a bolt on my rear diff?
I recently did the pinion nut fix and everything has been all good. Tonight i was looking at a machine and it looks like i may have a bolt missing. The picture is from the passenger side. I didn't...
View ArticlePlease Help guys!!!
I recently purchased a RZR 800s and due to a recent back injury a friend changed my fluids for me. Well the next day I noticed my trans was leaking!!! I took a socket to the bolt and all it does is...
View ArticleSuspension? Dual rate Springs?
I've read about people upgrading to dual rate springs on their 50" factory shocks, tried to click on the link but it is no longer useable. Does anyone know who sells them or other suggestions to gain...
View ArticleS&B partical separator?
Has anybody installed a S & B particle separator on a Rzr 800? S&B does not make a vehicle specific model for the 800. I have a UMP filter and want to add it.
View ArticleNew rookie needs info please
I have some questions about an RZR 800 that I may purchase and would like a dealer Polaris tech to PM myself? Thanks
View Article2011 Front Differential Sprague Carrier for 1332842
I'm struggling to find much information on my front differential. I can't find any sprague carriers except the original. Am I missing something? Do they work with numerous part numbers but they fail...
View ArticleClik here to view.
Help I'm really confused. Output seal leak.
Ok bought a used rzr 800. Changed all the fluids. Was no leaks beforehand. Did notice there was not much AGL came out of transfer case. A couple days later went out in garage and floor full of AGL....
View Articlegrease plugs
i have a 2014 800rzr and have 2 grease plugs on the rear (a) arm that are 90 degree and i still can not get a grease gun on the grease fitting anyone got any ideas, i tryed to raise it but no help????
View ArticleLooking to get 2 RZRs - advice please
Looking for a little advice from 800 owners. So, I sold my XP4 900 a year ago and the family misses it but would like to replace it with 2x 2-seaters as the kids didn't like riding in the back all...
View ArticleNo L in speedo
The rat has all gears and 4x4 indicator lights up. But when in low just shows -- . Tried moving shifter all threw the gears but L never shows up Sent from my SM-G930V using RZRForums.net mobile app
View Article2008 RZR 800 new to me
New to this forum and first time owner of a UTV. Never owned an ATV before either. I just bought a 2008 RZR with 2000 miles on it. What else should I do beside change the oil? Do these have 02...
View Article